RUBBER RESISTANCE TO THE EFFECTS OF AUTOMOTIVE GASOLINE COMPONENTS
Article Sidebar
Main Article Content
Abstract
This article presents the results of a study of the influence of gasoline components, such as aromatic hydrocar-bons, catalytic reforming gasoline, cyclohexane, isooctane, ethyl and n-butyl alcohols, and MTBE, on rubbers based on EPDM, NBR, HNBR, and FKM rubbers. Patterns of change in the weight of rubber samples under the influence of gas-oline components are established. It is shown that EPDM-based rubber is unsuitable for use as sealing materials when in contact with gasoline components due to a significant loss of mass and elasticity of the sample. The resistance of NBR and HNBR rubbers to destruction by aromatic gasoline components is approximately equal. However, HNBR-based rubbers exhibit higher resistance to swelling and destruction by isooctane and cyclohexane. The rubber sample based on fluororubber exhibits the best resistance to the effects of gasoline components. Significant swelling was observed only when immersed in MTBE. No signs of degradation of FKM-based rubber were detected upon contact with any of the studied gasoline components.
Article Details
This work is licensed under a Creative Commons Attribution 4.0 International License.
References
Варис В.С. Автомобильные эксплуатационные материалы: учеб. пособие. – Саратов: Профобразование, 2024. –136 c.
Касперович А.В., Шашок Ж.С., Вишневский К.В. Технология производства резинотехнических изделий: учеб.-метод. пособие для студентов специальности 1-48 01 02 «Химическая технология органических веществ, материалови изделий» специализации 1-48 01 02 05 «Технология пере работки эластомеров». – Минск: БГТУ, 2014. – 108 с.
Воздействие биодизельного и композиционного топлива на резину / С.В. Романцова, Р.Е. Аббасов, И.И. Фролови др. // Вестник ТГУ. – 2012. – Т.17, вып. 1. – С. 337–338.
Гуреев А.А., Азев В.С. Автомобильные бензины. Свойства и применение: учеб. пособие для вузов. – М.: Нефть т газ,1996. – 444 с.
Капустин В.М., Ершов М.А., Хакимов Р.В. Автомобильные бензины с высокооктановыми добавками: учеб. пособие. – М.: Рос. гос. ун-т нефти и газа (НИУ) им. И.М. Губкина, 2021. – 160 с.
Effects of gasoline with ester additives on the swelling behavior of rubbers / W. Pengfei, Y. He, S. Haiging et al. // ChinaPetroleum Processing and Petrochemical Technology. – 2018. – № 20(1). – Р. 44–51.
Осовская И.И., Савина Е.В., Левич В.Е. Эластомеры: учеб. пособие. – СПб.: ВШТЭ СПбГУТД, 2016. – 126 с.
Корнев А.Е., Буканов А.М., Шевердяев О.Н. Технология эластомерных материалов. – М.: НППА «Истек», 2009. –500 с.
Swelling behavior of rubber in the hydrocarbon liquids. / Q. Zhang, M. He, X. Zheng et al. // Hsi-An Chiao Tung Ta Hsueh /Journal of Xi'an Jiaotong University. – 2014. – № 48(11). – Р. 75–80. DOI: 10.7652/xjtuxb201411013
Абрамова Н.Л., Зобина М.В., Акопян Л.А. Релаксационные свойства гидрированных бутадиен-нитрильных эластомеров // Каучук и резина. – 2006. – № 6. – С. 5–9.
Коровина Ю.В., Щербина Б.И., Долинская Р.М. Пероксидная вулканизация гидрированного бутадиен-нитрильного каучука // Каучук и резина. – 2007. – №1. – С. 4–7.
Гидрирование бутадиен-нитрильных каучуков / Б.Ю. Анисимов, А.С. Дыкман, Н.С. Имянитов и др. // Каучук и резина. – 2007. – № 2. – С. 32–38.
Лысова Г.А., Донцов А.А. Гидрированные бутадиен-нитрильные каучуки. Свойства. Рецептуростроение. Применение: тематический обзор. – М.: ЦНИИТЭнефтехим, 1991. – 56 с.
Most read articles by the same author(s)
- V. IVANOV, T. VIGERINA, L. MIRZATAYEV, IMPROVEMENT OF THE REPAIR CYCLE OF AUTOMOBILE UNITS, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 1 (2026)
- V. IVANOV, A. VASKOVICH, G. UVAROV, DEVELOPMENT OF THE TECHNIQUE OF COMPLEX DIAGNOSING OF TECHNICAL CONDITION OF PISTON GROUP OF THE INTERNAL COMBUSTION ENGINE, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 11 (2015)
- V. IVANOV, КАК НАПИСАТЬ НАУЧНУЮ СТАТЬЮ (структура материала и организация работы), Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 3 (2016)
- V. IVANOV, COMPOSITION CENTERS IN PRODUCTION CASES LAYOUT MOTOR TRANSPORTATION COMPANIES, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 3 (2021)
- Е. KHASINEVICH, V. IVANOV, А. KORZOVA, G. KUCHARONAK, D. MOZALEVSKI, DEVELOPMENT AND EFFECTIVENESS EVALUATION OF AN ADAPTIVE ALGORITHM FOR PREVENTING TRAFFIC NODE BLOCKAGE, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 2 (2026)
- V. IVANOV, A. KASTRUK, O.L CHTEMPEL, T. VIGERINA, INFLUENCE OF SURFACE PLASTIC DEFORMATION ON GEOMETRICAL PARAMETERS WHEN RESTORING THE CRANKSHAFT BEARING JOURNALS, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 3 (2014)
- I. URBANOVICH, V. IVANOV, А. KORZOVA, G. KUCHARONAK, D. MOZALEVSKI, FORECASTING THE REDISTRIBUTION OF TRAFFIC FLOWS UNDER INCIDENT CONDITIONS ON AN URBAN ROAD NETWORK, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 2 (2026)
- A. YERMAK, P. GRISHIN, N. ARTEMENOK, PROSPECTS FOR THE USE OF ACTIVATED CLAY FOR PURIFICATION THE RESIDUAL PRODUCT OF THE PROCESS “UNICRACKING” , Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 3 (2019)
- V. IVANOV, D. MOZOLEVSKY, V. KUZMENKO, A. POLKHOVSKY’S, N. ARTYSHEVSKAYA, N. ERMAKOVA, TRAFFIC MANAGEMENT, ROAD ACCIDENTS, AUDIT, ANALYSIS OF ROAD TRAFFIC IMPROVEMENTS, SUGGESTIONS FOR ROAD IMPROVEMENT, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 11 (2014)
- V. IVANOV, REPORT AND SCIENTIFIC DISCUSSION DURING THE DISSERTATION DEFENSE, Vestnik of Polotsk State University. Part B. Industry. Applied Sciences: No. 2 (2025)